California Department of Resources Recycling and Recovery (CalRecycle) 

Tire-Derived Aggregate Projects

VTA Vasona Light Rail Line, Santa Clara County

Completed VTA Vasona TDA project.

Tire-Derived Aggregate as Vibration Mitigation

The vibration produced by the operation of rail rapid transit systems and railroads as measured at nearby buildings is significantly less than that required to damage a building, but can still be very annoying.

Reducing ground-borne vibration for rapid transit tracks usually takes the form of some type of "soft" or "special" track fastener, or a type of isolation system built under or incorporated as part of the track structure. The two types of track isolation systems most similar to the use of tire-derived aggregate (TDA) as an isolating medium are the ballast mat and the very costly floating slab track bed. Due to the large abundance of scrap tires which can be transformed into an energy-absorbing TDA material, an investigation was undertaken to determine the vibration attenuation properties of TDA and how TDA could be used to help attenuate ground-borne vibration.

In 1999-2000 two field tests were performed to determine the vibration attenuation and damping properties of TDA for potential use beneath rail lines and other applications. The first set of tests was performed at the Chicago Grade Landfill using two test pads consisting of a control section and three test sections. The second set of tests was performed using a short test and control section at the Santa Clara Valley Transportation Authority's Younger Yard where the shredded tires were installed under ballast and tie rail transit track.

These tests confirmed that the use of a one-foot thick layer of tire shreds located beneath the sub-ballast, ballast layers and ties of a light rail track section was an effective vibration mitigation measure. The effectiveness of this new technology fell between that of a conversional ballast mat section and that of a floating slab track bed. Based on these findings, the Valley Transit Authority (VTA) in San Jose chose to construct four sections of track, nearly 3000 feet, with the new TDA vibration mitigation underlayment, during its Vasona Light Rail Extension Project in 2001.

Cross section of TDA rail design showing rail ties
supported by one-foot thick layers of ballast, sub-ballast,
and tire shreds, separated by geotextile fabric membranes.

TDA placement alongside tracks.

Last updated: December 3, 2010
Tire Management http://www.calrecycle.ca.gov/Tires/
Tire Management Program Hotline: (866) 896-0600 (toll free) WasteTires@calrecycle.ca.gov